Page Modified 6/13/2012
Ford Service Manual
Quick Links
General Information
Chassis
Powertrain
Electrical
Body and Paint2009 Powertrain Control/Emissions Diagnosis Manual
0-Introduction1-Description and Operation2-Diagnostic Methods
3-Symptom Charts4-Powertrain DTC Charts and Descriptions
5-Pinpoint Tests6-Reference ValuesWiring Diagrams
Diagrams
ConnectorsFord Technical Service Bulletins
Links
All Ford Mustangs TSB
NHTSA TSB Lookup
S197Forum TSB
StangNet TSB
TSBs| Filter by year: |
ID | DESCRIPTION | Years |
|---|---|---|
| 04-09-06 | BODY—PAINT—IRON PARTICLE REMOVAL— INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION | 2004 - 2005 |
| 04-14-07 | SERVICE WIRING HARNESS REPLACEMENT GUIDELINES—SERVICE TIPS | 2005 - 2005 |
| 04-16-01 | ENGINE MISFIRE OR ROUGH RUNNING—COIL ON PLUG (COP) IGNITION SYSTEMS—WDS COP KIT DIAGNOSTIC TIPS | 1998 - 2005 |
| 04-24-05 | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR | 1999 - 2005 |
| 04-24-14 | GENERAL PCM PROGRAMMING PROCEDURES | 1997 - 2005 |
| 04-24-20 | LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS | 2002 - 2005 |
| 04-26-16 | WELD BONDING PROCEDURE | 2005 - 2005 |
| 04-26-22 | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) P035X AND NO DRIVEABILITY SYMPTOMS - 4.6L 3V ENGINE | 2005 - 2005 |
| 05-03-01 | MAF DIAGNOSTIC SERVICE TIP—VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM) | 2005 - 2005 |
| 05-04-08 | FUEL FILL SLOW, OR DIFFICULT TO FILL | 2005 - 2005 |
| 05-06-09 | INTERMITTENT CD PLAYER CONCERNS | 2005 - 2005 |
| 05-06-15 | AIR BAG WARNING LAMP ON—DTC B1891 IN RESTRAINTS CONTROL MODULE OR LAMP FLASHES CODE 53—VEHICLES BUILT BEFORE 10/02/2004 | 2005 - 2005 |
| 05-07-03 | AXLE WHINE—VEHICLES BUILT THROUGH 11/15/2004 | 2005 - 2005 |
| 05-08-06 | EXHAUST VIBRATION AT 850 RPM—4.0L ENGINE AND AUTOMATIC TRANSMISSION | 2005 - 2005 |
| 05-08-08 | GROWL/GRINDING NOISE IN 2ND OR 3RD GEAR DURING DECELERATION—TR3650 MANUAL TRANSMISSION—VEHICLES BUILT BEFORE 1/15/2005 | 2005 - 2005 |
| 05-09-03 | INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS | 2004 - 2006 |
| 05-09-11 | FRONT SUSPENSION POPPING NOISE WHILE TURNING RIGHT OR LEFT—VEHICLES BUILT BEFORE 4/8/2005 | 2005 - 2005 |
| 05-09-14 | CONVERTIBLE TOP RAISE/LOWER INSTRUCTIONS | 2005 - 2005 |
| 05-09-15 | MIL AND ETC LAMPS ON WITH BOTH DTC P2106 AND P2135—VEHICLES BUILT 11/29/2004 AND PRIOR | 2005 - 2005 |
| 05-09-18 | DISCHARGED BATTERY—CHARGING SERVICE TIPS | 1998 - 2006 |
| 05-10-19 | INTERMITTENT CD PLAYER CONCERNS—AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS | 2005 - 2005 |
| 05-14-04 | WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135—VEHICLES BUILT 11/29/2004 AND PRIOR | 2005 - 2005 |
| 05-15-02 | GROWL/GRINDING NOISE IN 2ND OR 3RD GEAR DURING DECELERATION - TR3650 MANUAL TRANSMISSION - VEHICLES BUILT BEFORE | 2005 - 2005 |
| 05-15-08 | TICKING AND/OR KNOCKING NOISE FROM ENGINE—4.6L/5.4L 3V | 2005 - 2005 |
| 05-15-12 | FUEL FILL SLOW, OR DIFFICULT TO FILL - VEHICLES BUILT BEFORE 4/26/2005 | 2005 - 2005 |
| 05-15-13 | FRONT SIDE MARKER LAMP RETAINING TAB BREAKING | 2005 - 2005 |
| 05-16-12 | SERVICE WIRING HARNESS REPLACEMENT GUIDELINES—SERVICE TIPS | 2005 - 2006 |
| 05-17-14 | LOOSE SEAT CUSHION COVER TRIM ON FRONT OF FRONT SEAT | 2005 - 2005 |
| 05-18-07 | WIRING—SOLDERING AND CRIMPING REPAIRS— SERVICE TIPS | 2000 - 2006 |
| 05-18-10 | BRAKE NOISE—VEHICLES BUILT BEFORE 3/8/2005 | 2005 - 2005 |
| 05-19-10 | LOOSE SEAT CUSHION COVER TRIM ON FRONT OF FRONT SEAT | 2005 - 2005 |
| 05-20-02 | REAR AXLE NOISE | 2005 - 2006 |
| 05-21-02 | LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS | 2005 - 2005 |
| 05-22-08 | WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING | 1998 - 2006 |
| 05-23-17 | DIAGNOSTIC TROUBLE CODE (DTC) P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V | 2005 - 2006 |
| 05-24-06 | CONVERTIBLE SYSTEM CONCERNS | 2005 - 2006 |
| 05-25-15 | MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V | 2005 - 2005 |
| 06-01-05 | DTC P1000 MAY NOT CLEAR IN HIGH ALTITUDE CONDITIONS | 2006 - 2006 |
| 06-02-09 | DTC P0340/P0344/P0345/P0349—4.6L 3V AND 5.4L 3V | 2005 - 2006 |
| 06-03-13 | FUEL FILL SLOW, OR DIFFICULT TO FILL | 2005 - 2006 |
| 06-04-01 | RATTLE/NOISE FROM THE CENTER STACK (RADIO/HEATER) OF THE INSTRUMENT PANEL OR GEARSHIFT AREA | 2005 - 2006 |
| 06-04-02 | BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS | 1998 - 2006 |
| 06-04-07 | TICKING AND/OR KNOCKING NOISE FROM ENGINE - 4.6L/5.4L 3V | 2005 - 2005 |
| 06-04-09 | A/C COMPRESSOR NOT OPERATIONAL / LOW FREON-SHAFT SEAL LEAKS | 2003 - 2006 |
| 06-05-04 | PARK BRAKE CABLE FREEZING/REAR BRAKES DRAGGING | 2005 - 2006 |
| 06-07-10 | MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V | 2005 - 2006 |
| 06-09-09 | HESITATION ON ACCELERATION AFTER LONG CRUISE | 2005 - 2006 |
| 06-09-11 | LOUD TICKING NOISE—3-VALVE ENGINES—STUCK LASH ADJUSTER | 2006 - 2006 |
| 06-10-01 | AIR CONDITIONER COMPRESSOR CLUTCH FAILURE—REVISED COMPRESSOR CLUTCH | 2005 - 2006 |
| 06-10-05 | 5R55S—TRANSMISSION FLUID LEAK | 2006 - 2006 |
| 06-10-10 | AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES | 2005 - 2007 |
| 06-10-13 | MIL P0463 OR ERRATIC FUEL GAUGE | 2005 - 2006 |
| 06-12-11 | LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS | 2005 - 2006 |
| 06-14-03 | AIR CONDITIONER COMPRESSOR CLUTCH FAILURE—REVISED COMPRESSOR CLUTCH | 2005 - 2006 |
| 06-15-02 | SPARK PLUG REMOVAL INSTRUCTIONS—5.4 3V | 2005 - 2009 |
| 06-15-08 | KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY | 1999 - 2006 |
| 06-17-08 | SERVICE WIRING HARNESS REPLACEMENT GUIDELINES—SERVICE TIPS | 2005 - 2007 |
| 06-18-16 | IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP | 1999 - 2006 |
| 06-19-02 | 8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS | 2005 - 2007 |
| 06-19-05 | CONVERTIBLE TOP WEAR | 2005 - 2007 |
| 06-19-08 | TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE—4.6L/5.4L 3V | 2005 - 2005 |
| 06-19-12 | DTC P0340/P0344/P0345/P0349—4.6L 3V AND 5.4L 3V | 2005 - 2006 |
| 06-21-07 | AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES | 2005 - 2007 |
| 06-21-19 | HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY) | 1997 - 2007 |
| 06-22-16 | CONVERTIBLE TOP WEAR - BUILT BEFORE 10/11/2006 | 2005 - 2007 |
| 06-22-18 | POWER WINDOW DIAGNOSIS | 2005 - 2007 |
| 06-25-15 | ALUMINUM BODY PANELS - CORROSION - SERVICE TIP | 2005 - 2007 |
| 06-26-01 | MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS | 1985 - 2007 |
| 06-26-02 | CARPET REMOVE AND REPLACE | 2005 - 2007 |
| 07-01-07 | MERCON ATF REPLACED BY MERCONâ V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS | 1996 - 2007 |
| 07-03-09 | MIL ON - DTC P0456 | 2005 - 2006 |
| 07-04-03 | LEATHER - WRAPPED STEERING WHEEL - LEATHER COMING LOOSE | 2000 - 2007 |
| 07-05-08 | BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS | 2000 - 2007 |
| 07-05-13 | DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE | 2005 - 2008 |
| 07-06-07 | SPOILER/DECK LID CONTACT | 2007 - 2007 |
| 07-07-08 | RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS) - SERVICE TIPS | 2005 - 2007 |
| 07-10-03 | AIR BAG WARNING LAMP ON—DTC 2295 IN RESTRAINTS CONTROL MODULE AND LAMP FLASH CODE 22—BUILT 3/1/2007- 4/15/2007 | 2007 - 2007 |
| 07-12-03 | RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS | 2005 - 2007 |
| 07-14-06 | WATER LEAK—FRONT FLOOR AREA | 2005 - 2008 |
| 07-16-07 | EXTERIOR DOOR HANDLE NOT FLUSH IN THE CLOSED POSITION | 2005 - 2008 |
| 07-17-06 | BUZZ/RATTLE FROM DOOR PANEL WHEN OPERATING AUDIO SYSTEM—VEHICLES BUILT BEFORE 8/2/2007 | 2005 - 2008 |
| 07-18-01 | FRONT SUSPENSION POPPING NOISE WHILE TURNING RIGHT OR LEFT - VEHICLES BUILT BEFORE 4/8/2005 | 2005 - 2005 |
| 07-18-02 | 4.0L AND 4.6L COUPE—FRONT END NOISE OVER BUMPS | 2005 - 2007 |
| 07-19-01 | CONVERTIBLE TOP WEAR - BUILT BEFORE 10/11/2006 | 2005 - 2007 |
| 07-20-03 | CONVERTIBLE TOP - TENSION CABLE NOISE - BUILT BEFORE 12/1/2006 | 2005 - 2007 |
| 07-21-12 | FUEL FILL SLOW, OR DIFFICULT TO FILL | 2005 - 2007 |
| 07-22-08 | 8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS | 2005 - 2007 |
| 07-23-01 | GRUNT/CREAK/SQUEAK/CHIRP NOISE FROM THE LOWER CONTROL ARM BUSHING OVER BUMPS - BUILT BEFORE 2/28/2007 | 2005 - 2007 |
| 08-02-04 | MANUAL TRANSMISSION SHIFTER BOOT NOISE - BUILT BEFORE 1216/2007 | 2005 - 2008 |
| 08-02-10 | 4.6L MANUAL TRANSMISSION - SEPARATOR PLATE BUZZ - BUILT BEFORE 12113/2007 | 2005 - 2008 |
| 08-03-04 | RATTLE/BUZZ/VIBRATION - TRANSMISSION CROSS-MEMBER EXHAUST MOUNT - BUILT BEFORE 12/3/2007 | 2005 - 2008 |
| 08-04-02 | COLD START FEAD HOOT—WHISTLE NOISE / BUILT BEFORE 1/28/2008 | 2007 - 2008 |
| 08-04-17 | ERRATIC FUEL GAUGE | 2005 - 2006 |
| 08-05-01 | SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS), MAY NOT SEEK ALL SIRIUS SATELLITE RADIO CHANNELS | 2008 - 2008 |
| 08-05-10 | 8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS | 2005 - 2007 |
| 08-07-06 | SPARK PLUG REMOVAL INSTRUCTIONS—4.6L 3V/5.4L 3V/6.8L 3V | 2005 - 2008 |
| 08-08-05 | 4.0L WITH MANUAL TRANSMISSION—4TH GEAR RATTLE/KNOCK NOISE ON ACCELERATION— 1800-2200 RPM APPROXIMATELY 45 MPH (72 KM/H) | 2005 - 2007 |
| 08-09-02 | UN-COMMANDED PERIMETER LIGHTING | 2007 - 2008 |
| 08-12-09 | INOPERATIVE RKE TRANSMITTER (KEY FOB)— DISCHARGED KEY FOB BATTERY | 2008 - 2008 |
| 08-17-03 | CONVERTIBLE—REAR QUARTER GLASS— TORN/SEPARATING QUARTER GLASS DIVISION BAR | 2005 - 2009 |
| 08-18-02 | MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM | 2006 - 2006 |
| 08-19-10 | 4.0L DTC’S P030X, P0300, P0316, P0172, P0175 OR DRIVABILITY CONCERN—VEHICLES BUILT BETWEEN 6/3/2008-7/21/2008 | 2009 - 2009 |
| 08-20-10 | 4.0L MANUAL TRANSMISSION—RPM FLUCTUATION DURING NEUTRAL COAST DOWN | 2005 - 2006 |
| 08-21-02 | SYNC SOFTWARE PROGRAMMING SERVICE TIPS | 2009 - 2009 |
| 08-21-06 | AXLE WHINE | 2005 - 2009 |
| 08-21-07 | POWER WINDOW FEATURE—BOUNCE BACK DIAGNOSTICS | 2005 - 2009 |
| 08-23-04 | SHUDDER ON ACCEL—POSSIBLE WRONG TRANS CROSSMEMBER ASSEMBLY INSTALLED (EXCLUDES GT 500) | 2005 - 2009 |
| 08-24-10 | A-PILLAR RATTLE NOISE | 2005 - 2009 |
| 08-26-07 | WATER LEAK—FRONT FLOOR AREA | 2005 - 2009 |
| 09-07-07 | 4.0L ENGINE BELT SQUEAL OR CHIRP NOISE ON COLD STARTUP | 2009 - 2009 |
| 09-07-09 | SYNC SOFTWARE UPDATE—VARIOUS ISSUES | 2009 - 2009 |
| 09-08-07 | AIR BAG WARNING LAMP ON—DTC 2295 IN RESTRAINTS CONTROL MODULE | 2007 - 2009 |
| 09-09-02 | SHELBY GT500—CLUTCH DRAG—BUILT BEFORE 9/1/2008 | 2007 - 2009 |
| 09-09-06 | 4.6L WITH TR3650 MANUAL TRANSMISSION—CLASH OR RASPY FEEL—SHIFTING INTO 2ND AND/OR 3RD GEAR | 2007 - 2008 |
| 09-09-07 | COLD START FEAD HOOT—WHISTLE NOISE | 2007 - 2008 |
| 09-12-12 | 5R55S/5R55N/5R55W TRANSMISSIONS - SHIFT CONCERNS, LOSS OF 2ND, 3RD AND 5TH GEAR, INCORRECT RATIO DTC'S - PROCEDURE TO INSPECT AND REPAIR SERVO PIN BORE WEAR | 2005 - 2009 |
| 09-14-08 | LUGGAGE COMPARTMENT LID SOLENOID STUCK OPEN | 2006 - 2010 |
| 09-18-16 | 4.6L MANUAL TRANSMISSION—SEPARATOR PLATE BUZZ—BUILT BEFORE 4/5/2009 | 2005 - 2010 |
| 09-19-17 | 4.6L WITH TR3650 MANUAL TRANSMISSION—CLASH OR RASPY FEEL—SHIFTING INTO 2ND AND/OR 3RD GEAR | 2007 - 2008 |
| 09-20-04 | AXLE WHINE | 2005 - 2010 |
| 09-20-10 | SPEAKER POP AND/OR RADIO INOPERATIVE/BLANK/LOCKED UP | 2008 - 2009 |
| 09-24-16 | GRUNT/CREAK/SQUEAK/CHIRP NOISE FROM THE LOWER CONTROL ARM BUSHING OVER BUMPS— BUILT ON OR BEFORE 8/3/2009 | 2005 - 2010 |
| 09-26-07 | 5.4L / 4.0L - DTC P0607 | 2008 - 2010 |
| 10-02-08 | SYNC SYSTEM DEFAULTS TO OR STAYS IN PRIVACY MODE, MULTIPLE VEHICLE LINES | 2008 - 2010 |
| 10-03-07 | REAR DRIVE AXLE VENT—OIL LEAK | 2005 - 2010 |
| 10-04-13 | CONVERTIBLE TOP - HEADLINER PULLED OUT FROM NUMBER 1 BOW | 2005 - 2010 |
| 10-05-09 | LUGGAGE COMPARTMENT LID SOLENOID STUCK OPEN | 2006 - 2010 |
| 10-23-08 | AIR BAG WARNING LAMP ON—DTC B2295 IN RESTRAINTS CONTROL MODULE | 2007 - 2009 |